广西顶博发电机组制造

13667715899

添加微信好友了解产品w13667715899

当前位置:首页 > 技术支持

又到暴雨潮湿季节了,广西顶博发电机组制造进水该怎么办?

2021-07-31
来源: 原创
106296
当梅雨季或台风天气季来为了方便接拉,有或许受洪灾、雷暴等必然洪涝的关系,因柴油密度车电站厂汽轮柴油密度机电站机IDC机房普遍是在低下室也许1楼会被水淹,一旦电站厂汽轮柴油密度机电站机收存隔离疏忽也许其余其原因水有或许从烟管走进发起机缸体。当柴油密度车电站厂汽轮柴油密度机电站机渗水的时,可以在正常运转请实时停止,并采取有效必要的的办法,重连外电源线及蓄干电池接驳线,同一时间检修有几个部件的渗水的条件。


When the rainy season or typhoon season comes, it may be affected by natural disasters such as flood and rainstorm. Because the diesel generator set room is generally in the basement or the first floor, it is easy to be flooded. If the generator set is poorly kept and protected or for other reasons, water may enter the engine cylinder from the smoke pipe. When water enters the diesel generator set, if it is running, please shut down immediately, take necessary measures, disconnect the external power supply and battery connection line, and check the water inflow at all parts at the same time.


广西顶博发电机组制造机房


检查广西顶博发电机组制造进水常见问题

1、查验泄压阀线路(排风系统管低点处或消音器)的排水的部件能否有冰流出。Check the exhaust pipe to see if there is water discharged from the drainage component.


2、查验气氛滤心底壳有无有渗漏,滤心有无被水浸渍。Check whether there is water in the air filter housing and whether the filter element is immersed in water.


3、查来发直流电机的外壳低部是不是也有积水怎么办。Check whether there is water accumulated at the bottom of the generator casing.


4、观察排热器、空调风扇、轴套等倒转构件能不短路。Check radiator, fan, coupling for blockage.


5、外有没有巧妙油、燃料或水的渗漏。Whether there is leakage of organic oil, fuel or water from the outside.


6、卸下来连杆室盖,观看是不是有漏电。审核发电厂机电机绕线耐压/环境污染环境。Remove the rocker chamber cover and observe whether there is water ingress. Check the insulation and ontamination of the generator windings.


7、在线检查测量操作配电线路和效果三极管的接地。在线检查测量操作面板面板开关组件、各义表、告警传动装置、打火面板开关。Check the insulation between the control circuit and the output circuit. Check the control panel module, each instrument, alarm device and start switch.


要注意:絕對不可以让水进入打火机的引燃室!Note: Never let water enter the combustion chamber of the engine!


接触不良净化处理步骤静音并网发直流电超临界锅炉漏液后的操作无法:Treatment  after water enter the generator:


当诊断重油密度生产发主轴电空调发动机组热车机的烧燃室沒有泡水,隔热遵循规定要求时,可起动重油密度生产发主轴电空调发动机组。在起动时要要留意一些故障 :When confirm there is no water in the combustion chamber  and the insulation meets the requirements,can start the generator. Pay attention to the following issues when starting:


1、在加载上升行那些检修,属于释放然油箱积水怎么办。不间断系统软件日益上电,观察分析是否能够有特别。Do all inspections before starting, including draining water in the fuel tank. The electrical system is gradually powered on, and observe whether there is any abnormality.


2、不断进行汽车发因素的周期不应高达5秒钟。若汽车发因素不可自燃,则檢查汽柴油聚氨酯保温管及电力漏电开关,1两分种后其次进行。Start the engine continuously shall not exceed 30 seconds. If the engine cannot catch fire, check the fuel line and electrical circuit, and start again after one or two minutes.


3、檢查起驱动力歌声有没有有越来越,有没有有刺激性气味。檢查不间断仪器仪表的提示 、提示屏提示 屏有没有断屏又或者提示 不清。


Check whether the engine sound is abnormal and whether there is a peculiar smell. Check whether the display of the electrical instrument and the LCD screen are broken or unclear.


4、紧密排查柴油发动机机油有压力和水温湿度,假如油压机或温湿度不一致合系统规定,应停用起思想。欠费后,排查第一次柴油发动机机油垂直面。Closely observe the oil pressure and water temperature. If the oil pressure or temperature does not meet the technical specifications, the engine should be shut down. After stopping, check the oil level.


当断定起思想能够进行进水、并网发电站机耐压不相适合条件时,请匆未经许可维修服务,应搜寻并网发电站发电装置组服务商的正规专业高技术人士的辅助。When it is judged that water may enter the engine and the insulation of the generator does not meet the requirements, do not repair it without authorization, and seek the help of professional technicians from the generator manufacturer.


降雨/湿潮环保,柴油密度生产发无刷电工作机组采用目光基本原则Key points for unit operation in rainstorm / humid environment


1、移动到周围环境的标准1. Placement environment requirements(1)在户外安放适用的机柜,需进行防水防雨罩的措施,系统配置防水防雨罩棚、静音模式箱等;


Rainproof measures shall be taken for units placed outdoors, and rainproof sheds, static speakers, etc. shall be equipped;


(2)空气能热泵机组底壳须有稳定可靠的自我保护地线极,对要有一般的中性粒细胞点马上地线极的生产发变频电动机,则须要由职业工作人员实行一般的中性粒细胞地线极;The shell of the unit must be reliably grounded. For generators requiring direct neutral grounding, the neutral grounding must be carried out by professionals;


(3)雷击单发的地方安全使用机械设备,请配备防雷部件。If machines are used in lightning prone areas, please configure lightning protection devices.


(4)请最好不要将空气能机组摆放在于地形地貌较低,路基不牢(泥沙砖面)简易 肾积水的特点;Please do not place the unit in a place with low terrain, weak foundation (soil ground) and easy to accumulate water;


(5)储放在地上室安全使用的机气,需了解地上室排水的、防水作业。For machines placed in the basement, drainage and moisture-proof work in the basement shall be done well.
报价:13667715899
安利文章内容
柴油发电机厂家 柴油发电机厂家 柴油发电机厂家 柴油发电机厂家 柴油发电机厂家